• Learn to say 'no' to the good so you can say 'yes' to the best. John C. Maxwell

See NASA Vehicle Assembly Building



A building so large that it has its own weather.

At an astonishing 160 meters (525 feet) tall, 218 meters (716 feet) long, and 158 meters (518 feet) wide, the VAB covers an area of eight acres and encloses a volume of about 3,665,000 cubic meters (129,428,000 cubic feet). To get an idea of how large that is, the total volume of the VAB is about 3.75 times that of Manhattan’s Empire State Building. That’s enough space to fit the volume of Pentagon inside and have plenty of room left over!

The VAB is so large, in fact, that it has its own weather. On humid days, rain clouds can form below the ceiling, requiring about 10,000 tons of air conditioning equipment to control the moisture. With this setup, the total volume of air in the building can be replaced in only one hour.

The records held by the VAB are not limited to its interior, however. The exterior boasts one of the largest American flags, completed with 6,000 gallons of paint. At 64 meters (209 feet) high and 33.5 meters (110 feet) wide, the stars are six feet across, the stripes are nine feet wide, and the blue portion is approximately the size of a regulation basketball court.

Originally built to accommodate the vehicle assembly for the Apollo and Saturn missions, the VAB underwent renovations to support the Space Shuttle. With the shuttle’s retirement slated for 2010, the VAB will serve as the construction site for the Ares vehicles. From this building, NASA’s space-bound vehicles leave through one of the building’s four doors. The doors, which are the largest in the world, each measure 139 meters (456 feet) high. While tall enough to easily fit the Statue of Liberty, the doors take 45 minutes to open or close.

From these doors, the six-million-pound Crawler-Transporter begins the slow process of moving the space vehicles to the launch pad several miles away. At a mere one mile per hour, and a gas-guzzling 42 feet per gallon, the Crawler can position the vehicle for launch with an accuracy of one inch.

While the exterior of the VAB can be seen regularly on guided tours of the Kennedy Space Center, opportunities to view the building’s interior are a much rarer occurrence.